DUI BlueHeat Owner's Manual

9BLUEHEAT™ SYSTEM__________UNCONTROLLED IF PRINTED QSP-711-101Mounting the SBS™ Canister (See FIG. 2)• The SBS™ housing is equipped with three 2 inch

Opening the SBS™ Canister1.The SBS™ should be dry and free of moisture before opening it.TheSBS™ should only be opened in a dry environment.2. Undo th

4.Align the SBS™ cap and canister body and firmly press the cap into thecanister with both hands.5. Close and latch the two stainless steel locking la

SBS™ Care and MaintenanceThe outside of the SBS™ should be rinsed with fresh running water and alldirt and salt residue removed.SBS™ Storage1.When sto

13BLUEHEAT™ SYSTEM__________UNCONTROLLED IF PRINTED QSP-711-101!!WARNING!!Do not charge the SBS™ battery pack whilein the SBS™ housing.!!WARNING!!Use

14BLUEHEAT™ SYSTEM__________UNCONTROLLED IF PRINTED QSP-711-101SBS™ CONTROLLERThe SBS™ Controller provides the diver with control at their fingertips.

Control Features (See FIG. 7)1.There are two separately controlled heating zones (A & B)a.A = Liner torso heatingb. B = Accessory gloves and/or so

16BLUEHEAT™ SYSTEM__________UNCONTROLLED IF PRINTED QSP-711-101SBS™ MODESThe SBS™ has 3 different modes that a diver can switch between to best meetth

SBS™ SaverSBS™ Saver extends your battery so you don’t have to worry about runningout of power for your light and heating.This System has two steps. F

4. Insert the electric suit port into the valve hole on the suit. Make sure toalign the suit port so that the wet connector is facing the direction th

1UNCONTROLLED IF PRINTED QSP-711-101DUI BLUEHEAT™ OWNER’S MANUALCongratulations on purchasing a DUI BlueHeat™ System. It has been carefullymanufacture

moisture transport.The combination of stretch materials is critical in thedesign of the Liner so that it places and holds the heating pads close andev

Installing the Accessory Wiring Harness1. Open the LEFT front zipper on the liner and insert the main powerconnector into the pocket, up around the ne

3.Take the left arm connector (shorter cable) and slide it into the LEFTpocket zipper and out the small thread hole in the LEFT arm pit.Thenslide the

PRE-DIVE CHECK & INSPECTIONPerform this BlueHeat™ System Pre-Dive Check and Inspection prior todressing and diving:1. Using the Controller, check

DIVING THE BLUEHEAT™ SYSTEMImportant Safety InformationDUI’s heated liner, accessory gloves and socks are designed for less than 7volts. Do not use th

6. If diving dry gloves and BlueHeat™gloves, put both BlueHeat™ gloves onnow. Make sure the connectors on thegloves are securely connected tothe wirin

Diving the BlueHeat™ Liner and AccessoriesThe following recommendations are made for non-overhead recreationaldiving:Activate your SBS™ just before en

26BLUEHEAT™ SYSTEM__________UNCONTROLLED IF PRINTED QSP-711-101POST DIVE CAREBlueHeat™ LinerThe BlueHeat™ Liner requires additional attention above an

APPENDIXWhy Lithium Iron Phosphate (LiFePO4) batteries?• LiFePO4have a higher energy density than other cells like Nickel MetalHydride (NiMH)• LiFePO4

O-RING SIZING CHART28BLUEHEAT™ SYSTEM__________UNCONTROLLED IF PRINTED QSP-711-101FIG. 21

2TABLE OF CONTENTSUNCONTROLLED IF PRINTED QSP-711-101Definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

29UNCONTROLLED IF PRINTED QSP-711-101BLUEHEAT™ SYSTEM__________

ARE YOU A RESPONSIBLE DIVER?RESPONSIBLE DIVER CODEAs a responsible diver, I understand and assume all the risks I may encounterwhile diving.My respons

3. Being familiar with and checking my equipment before and duringevery dive.As a Responsible Diver, I understand...• that simply owning my equipment

• postponing the dive is the correct action if I am suffering from a cold,hangover, flu or other health deficiency that may cause complications.• to b

3UNCONTROLLED IF PRINTED QSP-711-101DEFINITION OF IMPORTANT WORDS USEDIN THIS MANUALThroughout this manual, we will use certain words to call your att

IMPORTANT SAFETY INFORMATION!!! DANGER !!!The BlueHeat™ liner, accessory gloves and socks aredesigned to be used in a dry environment under adrysuit.

!! WARNING !!Ice diving (diving in water 40°F (5°C) or less) isextremely hazardous. Do not engage in ice divingunless you have been thoroughly trained

IMPORTANT SAFETY PRECAUTIONSBLUEHEAT™ AND DRYSUIT GUIDELINESThe BlueHeat™ System is designed to be used under a drysuit.The followingdrysuit safety pr

INTENDED USE AND FUNCTION OF THEBLUEHEAT™ SYSTEMDUI’s BlueHeat™ System is designed to provide the diver with supplementalheat greatly extending the di

BLUEHEAT™ SMART BATTERY SYSTEM (SBS™)The BlueHeat™ Smart Battery System is built around a Lithium IronPhosphate (LiFePO4) core battery pack. Its capac